Quick Answer: What voltage is too high for car battery?

Check the reading. A fully charged battery will typically display a voltmeter reading of about 12.6 to 12.8 volts. If your voltmeter is showing a voltage anywhere between 12.4 and 12.8, that means your battery is in good shape. Any voltage above 12.9 volts is a good indicator that your battery has excessive voltage.

Is 14.7 volts too high?

Charging voltages over 14.7 volts can prematurely dry the battery by boiling out electrolyte, and increase risk of a battery hydrogen gas explosion. … Less than 14.3 would be a “weak” alternator or regulator. Much less than 14.2 at a fast idle is bad wiring, bad alternator or regulator, or a bad connection or fuse link.

Is 15 volts too high?

To answer your question, yes, 15 volts is too high. Most car alternators that charge your battery after every start and provide power while the engine is running are usually regulated to between 13 and 14.0 volts. … It will increase in power with increasing voltage.

What happens if battery voltage is too high?

Voltage will become dangerously high. The battery can overcharge which will leave it useless. Engine components that aren’t designed to handle the pressure, temperature or power will be damaged. The alternator isn’t designed to handle excessive power and eventually it will burn out.

IT IS INTERESTING:  How do you replace a car condenser?

What voltage is too high for a 12V battery?

12-volt batteries supply useful energy only through a limited range — from over 14 volts (when fully charged and unrested) down to 10.5 volts in use/under load (when lights dim, pumps groan and TV pictures get small). No 12-volt battery will remain at over 14 volts for more than seconds unless it’s being charged.

How do I know if my alternator is overcharging?

Symptoms of Your Car Alternator Overcharging:

  1. Car Battery Voltage Gauge Reading is High. You notice a high voltage reading on your cars vehicle’s dashboard. …
  2. Car Battery Gets Hot When Charging. …
  3. Your Headlights Burn Out Quickly. …
  4. Your Car Battery is Bulging on Sides.

Can overcharging alternator kill battery?

Other reasons causing overcharging

Bad Alternator: An alternator that’s not providing enough voltage will eventually kill your battery. But it’s also possible for an alternator to overcharge. It may be the wrong alternator has been fitted, or it is providing too much voltage. Both problems can overcharge the battery.

What happens if an alternator is overcharging?

Alternators that overcharge will typically produce excess voltage to the battery, making the battery case swell up, become very hot and lose its electrolyte through boiling. Improperly jump-starting the vehicle can send a surge through the battery that destroys one or more cells in the battery or shorts it out.

What are signs of bad alternator?

7 Signs of a Failing Alternator

  • Dim or Overly Bright Lights. …
  • Dead Battery. …
  • Slow or Malfunctioning Accessories. …
  • Trouble Starting or Frequent Stalling. …
  • Growling or Whining Noises. …
  • Smell of Burning Rubber or Wires. …
  • Battery Warning Light on Dash.
IT IS INTERESTING:  How do you prime a fuel injected engine?

Can I drive with an overcharging alternator?

Overcharging causes excessive heat to be produced in batteries which can cause explosion, melt-down, boiling away of acid, premature corrosion of electode plates within the battery cause premature failure of the battery, the elctrodes can warp inside the battery and short out the battery and take all the electronics in …

What causes a car battery to have high voltage?

In order to push energy into the battery, a higher voltage of about 14 volts is created. … Higher than 15 volts indicates a fault in the charging system’s voltage regulator or related circuits. If it’s substantially excessive, this can cause electrical system and/or battery damage.

Can you ruin a car battery by overcharging it?

Overcharging a battery causes excessive gassing — the electrolyte gets hot and both hydrogen and oxygen gas are generated. On older vented batteries, the electrolyte could cook away, leaving the plates exposed and ruining them. On sealed batteries, the buildup of gases could cause the battery to burst.

What causes an alternator to put out High voltage?

Battery. Alternators that overcharge will typically produce excess voltage to the battery, making the battery case swell up, become very hot and lose its electrolyte through boiling. This surge disrupts the wiring in the alternator, causing an overcharging condition.

Car repair school